Go Back   ScootDawg Forums > Performance :: Maintenance :: Technical > 125cc - 249cc
Reply
 
Thread Tools Search this Thread Display Modes
Old 01-28-2013, 05:42 PM   #1
beo111   beo111 is offline
 
Join Date: Mar 2009
Location: Menomonee Falls, Wisconsin
Posts: 23
Scoot won't start

Hello Dawgs. I haven't had a problem in a long time but I'm having one now! I was riding my Roketa 150cc scoot through the beginning of December here in Wisconsin. It started to get too cold for me to ride so I put the scoot in the garage. It's now at the end of January and the weather is a little better (40 degrees in the garage), so i tried to start the scoot last week and it wouldn't do anything. It won't even turn over, but there's just a single click sound when I press the start button. I made sure the battery was charged and it still just makes the click sound which is coming from the started solenoid? I assume this indicates that the solenoid is good? I try to kick start it but it doesn't do anything either. Not sure what this could be, being that I was riding it just last month. Usually when the scoot doesn't start after not driving it for a while it's always the pilot jet being clogged. But it would still turn over. This one really has me puzzled. Any suggestions?



Login or Register to Remove Ads
  Reply With Quote
Old 01-28-2013, 06:06 PM   #2
richardthescooter1   richardthescooter1 is offline
 
richardthescooter1's Avatar
 
Join Date: May 2011
Location: Nanty Glo, Pa.
Posts: 163
If you bridge the two big nuts on the starter solenoid and it starts, then its a bad solenoid, if you bridge or jump the two nuts and doesn't start it could be a weak battery or bad starter.
  Reply With Quote
Old 01-28-2013, 06:28 PM   #3
teddy554   teddy554 is offline
 
teddy554's Avatar
 
Join Date: Sep 2011
Location: staunton va
Posts: 319
yeah would say its a bad battery but do the test the richardthescooter1 said to make sure then you can know for sure
__________________

2010 Cpi Oliver 70cc, naruku trans kit, downhill handle bars, tecnigas rsll pipe, s6 4g rollers, Vento R4 with 90cc 1e52qmf technigas next r 100cc pipe Naruku, 21mm race carb, s6 4.5 g rollers



Login or Register to Remove Ads
  Reply With Quote
Old 01-28-2013, 06:47 PM   #4
beo111   beo111 is offline
 
Join Date: Mar 2009
Location: Menomonee Falls, Wisconsin
Posts: 23
Thanks for the suggestion. I went to the garage and tried it but nothing has changed. I assume that the two terminals on the solenoid are positive right? Not one positive and one negative?
  Reply With Quote
Old 01-28-2013, 06:52 PM   #5
beo111   beo111 is offline
 
Join Date: Mar 2009
Location: Menomonee Falls, Wisconsin
Posts: 23
If I kick start the bike (even if the starter was bad) it should still start right?



Login or Register to Remove Ads
  Reply With Quote
Old 01-28-2013, 06:56 PM   #6
scootnwinn   scootnwinn is offline
 
scootnwinn's Avatar
 
Join Date: Aug 2011
Location: Tierra Azul, NM
Posts: 739
Right use a heavy gauge wire to touch them both at the same time if nothing happens your battery may be bad. You can also try jumping it with your cage (ENGINE OFF) if that works its the battery. Try that and report
__________________


Do not fear mistakes. You will know failure. Continue to reach out.
- Benjamin Franklin

Join the HARDCORE

1983 Honda GL650I SilverWing
  Reply With Quote
Old 01-28-2013, 06:57 PM   #7
scootnwinn   scootnwinn is offline
 
scootnwinn's Avatar
 
Join Date: Aug 2011
Location: Tierra Azul, NM
Posts: 739
Yes kick should work matter what try jumping it, might be easier
__________________


Do not fear mistakes. You will know failure. Continue to reach out.
- Benjamin Franklin

Join the HARDCORE

1983 Honda GL650I SilverWing
  Reply With Quote
Old 01-28-2013, 07:01 PM   #8
beo111   beo111 is offline
 
Join Date: Mar 2009
Location: Menomonee Falls, Wisconsin
Posts: 23
I did jump it with a heavy gauge wire, even took one of the wires off the terminal and put it on the other terminal. It just makes that single click sound when I hit the start button. I have digital volt meter on the bike and a multimeter and I'm getting the full 12+ volts. I checked the fuse near the battery and it's good also.
  Reply With Quote
Old 01-28-2013, 07:03 PM   #9
scootnwinn   scootnwinn is offline
 
scootnwinn's Avatar
 
Join Date: Aug 2011
Location: Tierra Azul, NM
Posts: 739
12 volts might be a bit low a good battery without a draw should read. 12.6 or so. Try jumping it with a car like I said
__________________


Do not fear mistakes. You will know failure. Continue to reach out.
- Benjamin Franklin

Join the HARDCORE

1983 Honda GL650I SilverWing
  Reply With Quote
Old 01-28-2013, 07:04 PM   #10
beo111   beo111 is offline
 
Join Date: Mar 2009
Location: Menomonee Falls, Wisconsin
Posts: 23
Tried jumping the battery with my 12 volt charger pack (which I use for dead batteries on cars) also but it didn't do anything.
  Reply With Quote
Old 01-28-2013, 07:04 PM   #11
beo111   beo111 is offline
 
Join Date: Mar 2009
Location: Menomonee Falls, Wisconsin
Posts: 23
Ok, I will try it with the car (engine off).
  Reply With Quote
Old 01-28-2013, 07:08 PM   #12
scootnwinn   scootnwinn is offline
 
scootnwinn's Avatar
 
Join Date: Aug 2011
Location: Tierra Azul, NM
Posts: 739
Also try touching starter side of the selonoid with positive jumper while the other side is grounded
__________________


Do not fear mistakes. You will know failure. Continue to reach out.
- Benjamin Franklin

Join the HARDCORE

1983 Honda GL650I SilverWing
  Reply With Quote
Old 01-28-2013, 07:25 PM   #13
beo111   beo111 is offline
 
Join Date: Mar 2009
Location: Menomonee Falls, Wisconsin
Posts: 23
Ok, just came back from the garage and tried jumping it with my car and still nothing. I just saw your last message and will go back down to jump it from the starter side.
  Reply With Quote
Old 01-28-2013, 07:27 PM   #14
scootnwinn   scootnwinn is offline
 
scootnwinn's Avatar
 
Join Date: Aug 2011
Location: Tierra Azul, NM
Posts: 739
Kicking is next you may have a bad starter. It may just be stuck from disuse.
__________________


Do not fear mistakes. You will know failure. Continue to reach out.
- Benjamin Franklin

Join the HARDCORE

1983 Honda GL650I SilverWing
  Reply With Quote
Old 01-28-2013, 07:46 PM   #15
beo111   beo111 is offline
 
Join Date: Mar 2009
Location: Menomonee Falls, Wisconsin
Posts: 23
Ok, back from the garage again and tried jumping from the starter side. Nothing happened once again. I tried kick starting it also and nothing. The dash lights up a little every time I try to kick start and the brake lights and blinkers work also. Yes it can be the starter, but doesn't explain the kick start. Sometimes I would use the kick start when I was still riding it just to make sure it still worked. I'm really puzzled by this one!
  Reply With Quote
Reply

Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


All times are GMT -4. The time now is 12:54 PM.

Powered by vBulletin® Version 3.8.4
Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.